3,5-DINITROBENZOYL CHLORIDE

acyl, halides, nitro 

BENZOYL CHLORIDE, 3,5-DINITRO-; 3,5-DINITROBENZOIC ACID CHLORIDE; C7H3CLN2O5; RTECS: DM6637000

Emergency Overview 

Color:  yellow to brown 

Change in color: Not available

Physical Form: crystals, flakes, powder

Odor:  pungent odor 

Health Hazards:  respiratory tract burns, skin burns, eye burns, mucous membrane burns, tears 

Physical Hazards:  May explode when heated. Flammable solid. Dust/air mixtures may ignite or explode. Contact with water or moist air may generate flammable and/or toxic gases. 

Short Term:  burns 

Long Term:  same as effects reported in short term exposure 

Short Term:  burns 

Long Term:  same as effects reported in short term exposure 

Short Term:  burns 

Long Term:  same as effects reported in short term exposure 

Short Term:  burns 

Long Term:  same as effects reported in short term exposure 

If adverse effects occur, remove to uncontaminated area. Give artificial respiration if not breathing. If breathing is difficult, oxygen should be administered by qualified personnel. Get immediate medical attention. 

Wash skin with soap and water for at least 15 minutes while removing contaminated clothing and shoes. Get immediate medical attention. Thoroughly clean and dry contaminated clothing before reuse. Destroy contaminated shoes. 

Immediately flush eyes with plenty of water for at least 15 minutes. Then get immediate medical attention. 

Contact local poison control center or physician immediately. Never make an unconscious person vomit or drink fluids. Give large amounts of water or milk. Allow vomiting to occur. When vomiting occurs, keep head lower than hips to help prevent aspiration. If person is unconscious, turn head to side. Get medical attention immediately. 

For inhalation, consider oxygen. Avoid gastric lavage or emesis. 

See Section 9 for Flammability Properties 

Severe fire hazard. Dust/air mixtures may ignite or explode. 

regular dry chemical, regular foam, water Large fires: Use regular foam or flood with fine water spray. 

Move container from fire area if it can be done without risk. Cool containers with water spray until well after the fire is out. Stay away from the ends of tanks. For fires in cargo or storage area: Cool containers with water from unmanned hose holder or monitor nozzles until well after fire is out. If this is impossible then take the following precautions: Keep unnecessary people away, isolate hazard area and deny entry. Let the fire burn. Dike for later disposal. Do not scatter spilled material with high-pressure water streams. Use extinguishing agents appropriate for surrounding fire. Avoid inhalation of material or combustion by-products. 

Avoid heat, flames, sparks and other sources of ignition. Do not touch spilled material. Small dry spills: Collect spilled material in appropriate container for disposal. Move containers away from spill to a safe area. Large spills: Wet down area with water. Dike for later disposal. Remove sources of ignition. Keep unnecessary people away, isolate hazard area and deny entry. 

Store and handle in accordance with all current regulations and standards. Store in a cool, dry place. Keep dry. Store in a tightly closed container. Avoid contact with water or moisture. Keep separated from incompatible substances. 

Component Exposure Limits 

Biological limit value 

Provide local exhaust ventilation system. Ventilation equipment should be explosion-resistant if explosive concentrations of material are present. Ensure compliance with applicable exposure limits. 

Eyes/Face Wear splash resistant safety goggles with a faceshield. Provide an emergency eye wash fountain and quick drench shower in the immediate work area. 

Wear appropriate chemical resistant clothing. 

Wear appropriate chemical resistant gloves. 

Under conditions of frequent use or heavy exposure, respiratory protection may be needed. Respiratory protection is ranked in order from minimum to maximum. Consider warning properties before use. Any air-purifying half-mask respirator equipped with organic vapor cartridge(s) in combination with an N95, R95, or P95 filter. The following filters may also be used: N99, R99, P99, N100, R100 or P100. Any air-purifying full-facepiece respirator (gas mask) with a chin-style, front-mounted or back-mounted organic vapor canister having an N100, R100, or P100 filter. Any powered, air-purifying respirator with a tight-fitting facepiece, organic vapor cartridge(s) and high-efficiency particulate filter(s). Any supplied-air respirator with a full facepiece that is operated in a pressure-demand or other positive-pressure mode. For Unknown Concentrations or Immediately Dangerous to Life or Health - Any supplied-air respirator with a full facepiece that is operated in a pressure-demand or other positive-pressure mode in combination with an auxiliary self-contained breathing apparatus operated in pressure-demand or other positive-pressure mode. Any self-contained breathing apparatus that has a full facepiece and is operated in a pressure-demand or other positive-pressure mode. 

ethers 

May explode when heated. Contact with water or moist air may form flammable and/or toxic gases or vapors. 

Avoid heat, flames, sparks and other sources of ignition. Minimize contact with material. Avoid inhalation of material or combustion by-products. 

combustible materials, bases, oxidizing materials, 

3,5-DINITROBENZOYL CHLORIDE: ALCOHOLS: Incompatible. BASES (STRONG): Incompatible. CHLORIDES: Incompatible. NITRATES: Incompatible. OXIDIZERS (STRONG): Fire and explosion hazard.

acid halides, phosgene, oxides of carbon, oxides of nitrogen 

Thermal decomposition products: hydrogen chloride, phosgene, carbon monoxide, carbon dioxide, oxides of nitrogen.

Will not polymerize. 

Component Analysis - LD50/LC50 

Component Carcinogenicity

None of this product's components are listed by ACGIH, IARC, NTP, DFG or OSHA

3,5-DINITROBENZOYL CHLORIDE See information on corrosive substances.

3,5-DINITROBENZOYL CHLORIDE See information on corrosive substances.

3,5-DINITROBENZOYL CHLORIDE See information on corrosive substances.

3,5-DINITROBENZOYL CHLORIDE See information on corrosive substances.

Component Analysis - Aquatic Toxicity 

Subject to disposal regulations: U.S. EPA 40 CFR 262. Hazardous Waste Number(s): D001. Dispose in accordance with all applicable regulations. 

Component Waste Numbers 

Component Marine Pollutants (IMDG) 

SARA Section 311/312 (40 CFR 370 Subparts B and C) 

Not listed under California Proposition 65 

The listed component(s) of this material have been checked for country-specific published classifications according to the Globally Harmonized System of Classification and Labeling (GHS). The results of the queries are displayed below. Please see the individual country listings, as additional interpretations or reference information may be available. For a reference list of H- or P-statements, please visit ChemADVISOR’s website at http://www.chemadvisor.com/product-resources/26-pure-substance-and-mixture-databases/247-ghs-hazard-and-physical-statements 

Australia GHS Classifications 

European Union GHS Classifications 

Indonesia GHS Classifications 

Japan GHS Classifications 

Korea GHS Classifications 

New Zealand GHS Classifications 

New Zealand GHS Labeling Information 

South Africa GHS Classifications 

Taiwan GHS Classifications 

No classification assigned. 

ACGIH - American Conference of Governmental Industrial Hygienists; ADR - European Road Transport; AU - Australia; BOD - Biochemical Oxygen Demand; C - Celsius; CA - Canada; CAS - Chemical Abstracts Service; CERCLA - Comprehensive Environmental Response, Compensation, and Liability Act; CN - China; CPR - Controlled Products Regulations; DFG - Deutsche Forschungsgemeinschaft; DOT - Department of Transportation; DSL - Domestic Substances List; EEC - European Economic Community; EINECS - European Inventory of Existing Commercial Chemical Substances; EPA - Environmental Protection Agency; EU - European Union; F - Fahrenheit; IARC - International Agency for Research on Cancer; IATA - International Air Transport Association; ICAO - International Civil Aviation Organization; IDL - Ingredient Disclosure List; IDLH - Immediately Dangerous to Life and Health; IMDG - International Maritime Dangerous Goods; JP - Japan; Kow - Octanol/water partition coefficient; KR - Korea; LEL - Lower Explosive Limit; LOLI - List Of LIsts™ - ChemADVISOR’s Regulatory Database; MAK - Maximum Concentration Value in the Workplace; MEL - Maximum Exposure Limits; NFPA - National Fire Protection Agency; NIOSH - National Institute for Occupational Safety and Health; NJTSR - New Jersey Trade Secret Registry; NTP - National Toxicology Program; NZ - New Zealand; OSHA - Occupational Safety and Health Administration; PH - Philippines; RCRA - Resource Conservation and Recovery Act; RID - European Rail Transport; RTECS - Registry of Toxic Effects of Chemical Substances®; SARA - Superfund Amendments and Reauthorization Act; STEL - Short-term Exposure Limit; TDG - Transportation of Dangerous Goods; TSCA - Toxic Substances Control Act; TWA - Time Weighted Average; UEL - Upper Explosive Limit; US - United States 

Reasonable care has been taken in the preparation of this information; however, the manufacturer makes no warranty whatsoever including the warranty of merchantability, expressed or implied, with respect to this information. The manufacturer makes no representations and assumes no liability for any direct, incidental, consequential, or other such damages resulting from its use or misuse. 

Supplier gives no warranty whatsoever, including the warranties of merchantability or of fitness for a particular purpose. Any product purchased is sold on the assumption the purchaser shall determine the quality and suitability of the product. Supplier expressly disclaims any and all liability for incidental, consequential or any other damages arising out of the use or misuse of this product. No information provided shall be deemed to be a recommendation to use any product in conflict with any existing patent rights. THIS SDS IS TO BE UTILIZED SOLELY AS A REFERENCE DOCUMENT AND IT IS NOT TO BE USED TO SATISFY THE DISTRIBUTION REQUIREMENTS OF OSHA'S HAZARD COMMUNICATION STANDARD (HCS) NOR CANADA'S CONTROLLED PRODUCT REGULATION (CPR). Read the Safety Data Sheet before handling product. Use of any information contained herein is provided at the reader's own risk and thus independent judgment by trained professionals must be utilized at all times. 

Copyright 1984-2016 ChemADVISOR, Inc "RTECS®" is a United States trademark owned and licensed under authority of the U.S. Government, by and through Accelrys/Biovia. Portions ©Copyright 2016, U.S. Government. All rights reserved