2-METHYLFURAN

heterocyclic 

METHYLFURAN; SILVAN; ALPHA-METHYLFURAN; 5-METHYLFURAN; STCC 4908210; UN 2301; C5H6O

Emergency Overview 

Color:  colorless 

Change in color: Not available

Physical Form: liquid

Odor:  sweet odor 

Health Hazards:  harmful if inhaled, respiratory tract irritation, eye irritation 

Physical Hazards:  Extremely flammable liquid and vapor. Vapor may cause flash fire. Explosive if dry. May form peroxides during prolonged storage. 

Short Term:  irritation, headache, drowsiness, symptoms of drunkenness 

Long Term:  asthma 

Short Term:  no information on significant adverse effects 

Long Term:  no information on significant adverse effects 

Short Term:  irritation 

Long Term:  same as effects reported in short term exposure 

Short Term:  nausea, vomiting, headache 

Long Term:  no information on significant adverse effects 

If adverse effects occur, remove to uncontaminated area. Give artificial respiration if not breathing. Get immediate medical attention. 

Wash skin with soap and water for at least 15 minutes while removing contaminated clothing and shoes. Get medical attention, if needed. Thoroughly clean and dry contaminated clothing and shoes before reuse. 

Flush eyes with plenty of water for at least 15 minutes. Then get immediate medical attention. 

Contact local poison control center or physician immediately. Never make an unconscious person vomit or drink fluids. When vomiting occurs, keep head lower than hips to help prevent aspiration. If person is unconscious, turn head to side. Get medical attention. 

See Section 9 for Flammability Properties 

Severe fire hazard. The vapor is heavier than air. Vapors or gases may ignite at distant ignition sources and flash back. Vapor/air mixtures are explosive. 

alcohol-resistant foam, carbon dioxide, regular dry chemical, water Large fires: Use alcohol-resistant foam or flood with fine water spray. 

Move container from fire area if it can be done without risk. Cool containers with water spray until well after the fire is out. Stay away from the ends of tanks. For fires in cargo or storage area: Cool containers with water from unmanned hose holder or monitor nozzles until well after fire is out. If this is impossible then take the following precautions: Keep unnecessary people away, isolate hazard area and deny entry. Let the fire burn. Withdraw immediately in case of rising sound from venting safety device or any discoloration of tanks due to fire. For tank, rail car or tank truck: Evacuation radius: 800 meters (1/2 mile). Water may be ineffective. 

Avoid heat, flames, sparks and other sources of ignition. Remove sources of ignition. Stop leak if possible without personal risk. Reduce vapors with water spray. Small spills: Absorb with sand or other non-combustible material. Collect spilled material in appropriate container for disposal. Large spills: Dike for later disposal. Keep unnecessary people away, isolate hazard area and deny entry. Stay upwind and keep out of low areas. 

Store and handle in accordance with all current regulations and standards. 

Component Exposure Limits 

Biological limit value 

Provide local exhaust ventilation system. Ventilation equipment should be explosion-resistant if explosive concentrations of material are present. Ensure compliance with applicable exposure limits. 

Eyes/Face Wear splash resistant safety goggles. Provide an emergency eye wash fountain and quick drench shower in the immediate work area. 

Wear appropriate chemical resistant clothing. 

Wear appropriate chemical resistant gloves. 

Under conditions of frequent use or heavy exposure, respiratory protection may be needed. Respiratory protection is ranked in order from minimum to maximum. Consider warning properties before use. Any supplied-air respirator with a full facepiece that is operated in a pressure-demand or other positive-pressure mode. Any self-contained breathing apparatus that has a full facepiece and is operated in a pressure-demand or other positive-pressure mode. For Unknown Concentrations or Immediately Dangerous to Life or Health - Any supplied-air respirator with a full facepiece that is operated in a pressure-demand or other positive-pressure mode in combination with an auxiliary self-contained breathing apparatus operated in pressure-demand or other positive-pressure mode. Any self-contained breathing apparatus that has a full facepiece and is operated in a pressure-demand or other positive-pressure mode. 

alcohol, ether 

Avoid contact with air. May form explosive peroxides. Explosive if dry. 

Avoid heat, flames, sparks and other sources of ignition. Containers may rupture or explode if exposed to heat. 

oxidizing materials 

TERPINOLENE: OXIDIZING MATERIALS: Reacts vigorously.

oxides of carbon 

Thermal decomposition products: oxides of carbon.

Will not polymerize. 

Component Analysis - LD50/LC50 

Component Carcinogenicity

None of this product's components are listed by ACGIH, IARC, NTP, DFG or OSHA

No data available Some furan derivatives may cause irritation and ulceration of nasal mucous membranes 377 ppm of 2-methylfuran for four hours is the lowest lethal concentration reported for rats No data is available for systemic effects of this chemical Some furan derivatives may cause headache, dullness, drowsiness and other symptoms of central nervous system depression.

No data available for 2-methylfuran Some furan derivative may cause asthma after prolonged or repeated exposure.

No data available Some furan derivatives may cause a burning sensation and then a slight erythema.

No data available Some furan derivatives may cause dermatitis after prolonged exposure.

May cause irritation 500 mg/kg applied to the eye of a rabbit for 24 hours caused mild irritation.

Prolonged exposure may cause conjunctivitis.

168 mg/kg given orally to rats was a lethal dose for 50% of the rats tested No specific symptoms of illness via ingestion were available Some furan derivatives may cause headache, nausea, and vomiting

No data available for this specific chemical Symptoms for furan derivatives are nausea, vomiting, jaundice, and acute polyneuritis.

Component Analysis - Aquatic Toxicity 

Dispose in accordance with all applicable regulations. 

Component Waste Numbers 

ADR Tunnel Code Restrictions 

Component Marine Pollutants (IMDG) 

SARA Section 311/312 (40 CFR 370 Subparts B and C) 

Not listed under California Proposition 65 

Canadian WHMIS Ingredient Disclosure List (IDL) 

Germany Water Classification 

The listed component(s) of this material have been checked for country-specific published classifications according to the Globally Harmonized System of Classification and Labeling (GHS). The results of the queries are displayed below. Please see the individual country listings, as additional interpretations or reference information may be available. For a reference list of H- or P-statements, please visit ChemADVISOR’s website at http://www.chemadvisor.com/product-resources/26-pure-substance-and-mixture-databases/247-ghs-hazard-and-physical-statements 

Australia GHS Classifications 

European Union GHS Classifications 

Indonesia GHS Classifications 

Japan GHS Classifications 

Japan GHS Labeling Information 

Korea GHS Classifications 

Korea GHS Labeling Information 

New Zealand GHS Classifications 

New Zealand GHS Labeling Information 

South Africa GHS Classifications 

Taiwan GHS Classifications 

Taiwan GHS Labeling Information 

No classification assigned. 

ACGIH - American Conference of Governmental Industrial Hygienists; ADR - European Road Transport; AU - Australia; BOD - Biochemical Oxygen Demand; C - Celsius; CA - Canada; CAS - Chemical Abstracts Service; CERCLA - Comprehensive Environmental Response, Compensation, and Liability Act; CN - China; CPR - Controlled Products Regulations; DFG - Deutsche Forschungsgemeinschaft; DOT - Department of Transportation; DSL - Domestic Substances List; EEC - European Economic Community; EINECS - European Inventory of Existing Commercial Chemical Substances; EPA - Environmental Protection Agency; EU - European Union; F - Fahrenheit; IARC - International Agency for Research on Cancer; IATA - International Air Transport Association; ICAO - International Civil Aviation Organization; IDL - Ingredient Disclosure List; IDLH - Immediately Dangerous to Life and Health; IMDG - International Maritime Dangerous Goods; JP - Japan; Kow - Octanol/water partition coefficient; KR - Korea; LEL - Lower Explosive Limit; LOLI - List Of LIsts™ - ChemADVISOR’s Regulatory Database; MAK - Maximum Concentration Value in the Workplace; MEL - Maximum Exposure Limits; NFPA - National Fire Protection Agency; NIOSH - National Institute for Occupational Safety and Health; NJTSR - New Jersey Trade Secret Registry; NTP - National Toxicology Program; NZ - New Zealand; OSHA - Occupational Safety and Health Administration; PH - Philippines; RCRA - Resource Conservation and Recovery Act; RID - European Rail Transport; RTECS - Registry of Toxic Effects of Chemical Substances®; SARA - Superfund Amendments and Reauthorization Act; STEL - Short-term Exposure Limit; TDG - Transportation of Dangerous Goods; TSCA - Toxic Substances Control Act; TWA - Time Weighted Average; UEL - Upper Explosive Limit; US - United States 

Reasonable care has been taken in the preparation of this information; however, the manufacturer makes no warranty whatsoever including the warranty of merchantability, expressed or implied, with respect to this information. The manufacturer makes no representations and assumes no liability for any direct, incidental, consequential, or other such damages resulting from its use or misuse. 

Supplier gives no warranty whatsoever, including the warranties of merchantability or of fitness for a particular purpose. Any product purchased is sold on the assumption the purchaser shall determine the quality and suitability of the product. Supplier expressly disclaims any and all liability for incidental, consequential or any other damages arising out of the use or misuse of this product. No information provided shall be deemed to be a recommendation to use any product in conflict with any existing patent rights. THIS SDS IS TO BE UTILIZED SOLELY AS A REFERENCE DOCUMENT AND IT IS NOT TO BE USED TO SATISFY THE DISTRIBUTION REQUIREMENTS OF OSHA'S HAZARD COMMUNICATION STANDARD (HCS) NOR CANADA'S CONTROLLED PRODUCT REGULATION (CPR). Read the Safety Data Sheet before handling product. Use of any information contained herein is provided at the reader's own risk and thus independent judgment by trained professionals must be utilized at all times. 

Copyright 1984-2016 ChemADVISOR, Inc "RTECS®" is a United States trademark owned and licensed under authority of the U.S. Government, by and through Accelrys/Biovia. Portions ©Copyright 2016, U.S. Government. All rights reserved